还剩10页未读,继续阅读
本资源只提供10页预览,全部文档请下载后查看!喜欢就下载吧,查找使用更方便
文本内容:
编制依据1工程概况1临水用水概述1临时用水计算1水源选择3施工现场临时排水、排污4高压雾化降尘措施5消防灭火器具的设置5安全措施5职业、安全、健康管理规定7施工现场平面布置图
81.编制依据:n郑州航空港经济综合实验区(郑州新郑综合保税区)合村并城建设项目南区16号地安置区工程位于郑州航空港区,东至领航路、南至新港九路、西至航兴路、北至风华路,总规划用地面积约108亩,总规划建筑面积约
19.24万平方米其中地上
14.34万平方米,地下
4.66万平方米,人防建筑面积
1.57万平方米,地上建筑分为住宅、商业和幼儿园三部分临时用水概述本工程现场临时供水主要包括生产用水、生活用水和消防用水三种生产用水包括工程施工用水、施工机械用水生活用水包括生产区生活用水和生活区生活用水消防用水主要包括生产区、办公区及生活区的消防用水临时用水计算1施工用水因本工程采用商品径,现场施工用水主要集中在砌筑、抹灰、冲洗模板、混凝土养护、楼地面水泥砂等;施工用水定额为冲洗模板50L/m2,混凝土养护200L/m3,施工生产总用水量按最不利考虑,施工高峰期每个台班工作量为混凝土养护1500m3冲洗模板5000m2么=K211T8x3600式中ql——施工生产用水量L/s;K1——未预见的施工用水系数,取
1.1;Q1——日工程量生活用水定额,取值如下表;N1——施工生产用水定额;T1——有效工作日,按天计算;t——每天工作班数;K2——用水不均衡系数,取
1.50ql=l.1X
1.5X15000*200+50000X5/8X3600=
18.6L/s2施工机械用水量计算因无特殊机械,故施工机械用水量q2忽略不计3现场生活用水q3按主体结构工程施工阶段按1500人计算=PNK3rx8x3600式中P1施工现场高峰昼夜人数P1=1500人N3——施工现场生活用水定额25L/人•班K4——用水不均衡系数取
1.4t——每天工作班数班q3=
0.91L/S4施工现场设生活区用水量=PXNXK”4243600式中P2生活区P2=1500人N4——施工现场生活用水定额100L/人•班K5——用水不均衡系数取
2.25o计算得q4=
4.OL/S5消防用水q5按火灾同时发生次数为2次,故选用q5=20L/S6总用水量Q按照ql+q2+q3+q4q5的原则,总用水量Q=30L/S考虑用水损失Q=30X1+10%=33L/S7供水管径计算D=[4Q/nv1000]
0.5式中D—配水管直径mm;Q—总供水量L/sv—管网经济流速m/s取
1.8m/s;则供水管径由计算公式计算得D=[4X33/
3.14X
1.8X
100010.5=
0.49m取供水管径D二150mm水源选择1施工现场及生活区打井作为水源2生活区采用无塔供水,水罐30m3压力
0.3Mpao主管道采用DN100镀锌钢管沿生活区周边辐射,小于等于DN50的给水管采用PPR管3按照施工安排,现场设置2套变频供水设备,2个蓄水水箱40静单套供水设备流量48m3/H扬程97米给水设备分别布置在现场的东北与西北角管网采用DN150钢管沿工地四周环状布置,同时将两套供水设备联通两套设备前期用水量小时可以交替使用,后期用水量增大时可以同时启用管网每隔30米引出DN50管道伸向基坑周边,末端设DN20球阀6个引入楼内的竖管采用DN100镀锌钢管沿竖井引至各楼层4临时给水管网沿周边道路敷设,采用直埋方式,管道埋设深度为400mni明设管道冬季做防冻处理5管道系统安装完毕后,应进行水压试验,试验压力为l.2MPa其压力保持在2小时,无明显渗漏为合格具体布置详见临时用水平面布置图施工现场临时排水、排污现场排水主要为生产排水、雨水排水和厕所污水排水1施工现场排污基坑周围设置排水沟,施工区内每40口设置一个雨水口收集排水沟内汇集的雨污水,尺寸mxmxo.8n]雨污水经沉沙池沉淀后,排入市政排污管道在场地东北角砌筑4*3*2m化粪池,现场公共卫生间污水排入化粪池,定期清理2生活区排污工人厕所化粪池容积计算本工程办公区施工时共设置厕所1处;生活区共设置厕所2处,化粪池为现场厕所和食堂污水服务,服务人数按1200人考虑,因此处没有市政管道可以排污,经综合考虑,生活区南面砌筑4*8*
3.5m化粪池两个,东面砌筑3*8*25化粪池两个,3*16*2m渗透池一个,定期清理3厨房生活污水厨房生活污水经隔油池后排入化粪池4雨水及施工废水施工现场道路边设400X400排水沟,雨、废水排到排水沟内,建筑物内的施工废水由集水坑汇集后用潜污泵排至室外雨水口处,明排水沟水汇集至落底雨水口排至市政管网,沉淀池定期清理生活区雨水设置雨水篦子,地下埋设雨水管道及砌筑雨水井,汇总流入化粪池为满足市政环卫部门对运输清洁及施工现场场容场貌的要求,现场入口处设置冲洗槽,主要满足汽车出场的清洗5临时用水系统的维护与管理施工时应注意保证消防管路畅通,消防栓箱内设备完备且箱前道路畅通,无阻塞或堆放杂物宝贵的水源要求我们加强管理用水,严禁出现长流水的浪费现象,水龙头均采用陶瓷芯密闭型龙头,现场临水使用设专人负责应加强现场厕所的卫生管理,及时冲洗、清扫、消毒,保持整洁、无臭味散发指定专人打扫、清理,并严格进行卫生间制度管理施工现场、办公区应及时清扫,保证干净、无积水严格执行环境管理体系的有关规定高压雾化降尘措施
1.为提倡节能环保,为施工现场创造一个良好的施工环境,在施工区主干道设置高压雾化降尘系统,水源引自环网水管,增加一台管道雾化加压泵,设置DN20镀锌钢管,每隔4米设置一个高压雾化喷头,定期开启,防尘降噪
2.设置塔吊喷淋系统,起到防尘及夏季高温主体施工层降温作用消防灭火器具的设置生活区及项目办公区均设置充装量5Kg的磷酸铉盐干粉灭火器,每三户配备两个灭火器,置于灭火器箱内,放在走廊靠近墙边处灭火器应平均布置,不能过于分散或集中现场设置的各种消防设施不得随意挪用损坏安全措施
(1)施工人员进入现场之前必须进行安全教育,牢固树立“安全第
一、预防为主”的安全方针
(2)施工现场的特殊作业人员必须经过专门培训,考试合格获得相应证书,严禁无证作业
(3)进入施工现场的人员必须正确配戴安全帽,系好下额带按照作业要求正确穿戴个人防护用品
(4)施工现场用火应申请办理用火证,并派专人看火,严禁在禁止吸烟的地方吸烟,动火
(3)焊接敷设水平消防干管时必须移开易燃物,消防立管管道连接采用卡箍连接方式,管道支架预加工好后,运往施工现场内组装,避免或减少在建筑物内的焊接作业
(5)所有靠近外墙及临边洞口的施工,当必须使用电气焊时,在施焊部位设置防护平台(可用钢筋制作成两个半圆柱状,其直径不小于3倍立管管径,敷设石棉布,防止焊渣飞溅)
(6)所有靠近外墙及洞口的施工,当必须使用电气焊时,先通知土建项目部共同清理焊接作业周边及下方场所内的所有易燃物,采用石棉布在焊接周围做好遮挡必须安排两名以上的看火人员,分别在楼上楼下看火,配备合格、有效、足够的灭火器材当外墙面有易燃物,无法转移或遮挡时,应先在墙面浇水且每层设置看火人员如果达不到上述条件,不允许施工
(7)上班作业前应认真查看在施工洞口、临边安全防护和脚手架护栏、挡脚板、立网是否齐全、牢固脚手板是否按间距要求放正、绑牢,有无探头板和空隙
(8)在没有可靠安全防护设施的高处(32m)必须系好安全带不得穿硬底和带钉易滑的鞋,不得向下投掷物料,严禁赤脚穿拖鞋进入施工现场
(9)班组长或专(兼)职安全员必须每日对作业环境、设施、设备进行认真检查,发现不安全隐患立即解决下班前进行确认检查,机电是否拉闸、断电、门是否己上锁、用火是否熄灭,做到活完料净场地清,确认无安全隐患后方可离开,要注意来往行驶车辆
(10)施工人员在施工区域内禁止嬉戏打闹,由于施工现场面积狭窄,在现场内不满18周岁的未成年工人,不得从事建筑工程施工作业施工人员需经体检合格后方可进入现场作业凡患有高血压、心脏病、癫痫病、晕高或视力较差的人员均不得进入现场作业
(11)高空作业(超过2米高,含2米),必须系好安全带,按规范系在操作者腰、裆部,另一端必须系在可靠牢固的固定物上,安全带绳长不得超过1米
(12)脚手架板应搭设牢固,不得有探头板,要将两头板端用铁丝绑扎牢固使用人字梯时,要将梯子中部用铁丝(链)连接牢固,梯脚四脚应用橡胶皮绑扎包上,防止梯脚与地面打滑,发生意外,梯脚分开角度上部应在35度;梯脚下部分开角度75度为宜,并且应设人在下扶梯,站在梯上作业人必须系好安全带安全带使用耍求按照第3条执行,严禁系再梯框上
(13)使用管钳拧、上管件时,一定要将管钳卡牢,己防止管钳打滑,用力过猛,摔伤施工人员
(14)挖管道沟土的要求必须按规定做“V”形放坡度,沟梆两侧需用木板顶靠支撑挖土时严禁偷懒“挖猫洞”、“挖地道气及时散开管道沟两边上堆积的浮土,防止土层坍塌伤人
(15)现场使用各种机具前要进行检查,应保证绝缘良好,并有可靠的接零线接地保护漏电保护装置灵敏有效
(16)现场在使用砂轮锯时,要注意远离易燃易爆物品在使用过程中其前而要设置一道防护板,防止切割作业时火花飞溅砂轮机在更换锯片时,必须拉闸断电,严禁使用砂轮机打磨钢材断管作业时,使用砂轮机要压力均匀,人站在砂轮片旋转方向的侧面
(17)在使套丝机时,严禁带手套,袖口要扎紧机械运转过程中不得进行维修保养
(18)压力案上不得放重物和立放套丝扳,手工套丝时,应防止扳机滑落
(19)使用手锤、大锤时严禁带手套,手和锤柄均不得有油污用锤方向附近不得有人停留
(20).操作水钻、电锤及手电钻时,钻头与接触面必须垂直,用力不宜过大人体和手不得摆动孔洞将要钻通时,应减小压力,以防钻头扭断
(21).电焊机使用前必须检查绝缘情况,线缆把钳不得腐蚀、受潮及松动电焊机必须设单独电源开关,自动断电装置一次电源不大于5米,二次电源不大于30米两侧接线应压接牢固,焊机必须安装可靠,防护罩外壳必须设可靠的接零或接地保护职业、安全、健康管理规定电气焊操作人员应穿电焊工作服、绝缘鞋和戴电焊手套、防护面罩等安全用品高空作业时必须系好安全带在密闭容器内施焊作业时,应采取通风设施间歇作业时焊工应到外面休息并设专人监护,监护人员应熟知焊接操作规程和抢救方法清除焊渣时应佩戴防护镜和面罩焊条头应集中堆放患有眼病、皮肤病、气管炎、结核病者不宜从事油漆作业油漆作业时操作人员出现头痛、恶心、心闷和心悸等症状,应停止作业,到户外通风处换气使用鲨子剔墙眼应戴防护眼镜,寥子毛刺应及时清理掉不得安排未成年工从事接触有职业病危害的工作对有心脏病,高血压等职业禁忌的人员,不得安排从事与其相关的高温作业管道保温时,操作人员必须戴口罩、风帽、风镜、手套、穿工作服贯彻执行各项劳动保护条令、规程和规定,及时协调解决有关安全卫生方面的问题,促进改善劳动条件,认真维护工人安全健康的权益施工现场平面布置图a kmiM期时mmm辍制盹林椭』成也辆m.I、珊顺脱0叩储碱,见碱搠涮聊松斜DN15嘲耕㈱耕N辘眯拙DN50髓撇眦械DN2嘛6乞奴辆嫩蜘N1麟醐,脱源醐.烦娜棚蹶撇枉檄卿郴.
5、姗椰蹴鼬痫.
6、官献锻跚粗泓
7、圳瀚蜘x3x淑斜4x4x
204.5x5x
504.谢用雌x3x惭以x株濯H,5x5x5桢X.
8、催略瞅脩袖疆麟Y,妹酬联捱燃,㈱貌域觥獭湖.
9、物相褓辙牖炳L序号法律、法规、施工规范名称备注1中华人民共和国建筑法2中华人民共和国环境保护法3中华人民共和国水污染防治法4中华人民共和国安全生产法5给水排水设计手册(第二版)6建筑给水排水及采暖工程施工质量验收规范(GB50242-2002)7甲方提供的现场布置图8现场水源点及污水排放点9中建八局二公司工程现场相关管理制度。